Household and similar electrical appliance - Safety -
Particular requirements for pumps
1 Scope
This clause of GB 4706.1-2005 is replaced by the following.
This part deals with the safety of electric pumps for liquids having a temperature not exceeding 90 °C, intended for household and similar purposes, their rated voltage being not more than 250 V for single-phase appliances and 480 V for other appliances.
Note 1: Examples of appliances within the scope of this part are
——aquarium auxiliary pump;
——pumps for garden ponds;
——shower-boost pumps;
——sludge pumps;
——submersible pumps;
——table fountain pumps;
——vertical wet pit pumps.
Appliances not intended for normal household use, but that nevertheless may be a source of danger to the public, such as appliances intended to be used by laymen in shops, in light industry and on farms, are within the scope of this part.
As far as is practicable, this part deals with the common hazards presented by appliances that are encountered by all persons in and around the home.
However, in general, it does not take into account:
——the use of appliances by young children or infirm persons without supervision;
——playing with the appliance by young children.
Note 2: Attention is drawn to the fact that
——for appliances intended to be used in vehicles or on board ships or aircraft, additional requirements may be necessary;
——in many countries additional requirements are specified by the national health authorities, the national authorities responsible for the protection of labour and similar authorities.
Note 3: This part does not apply to
——stationary circulation pumps for heating and service water installations (GB 4706.71/IEC 60335-2-51);
——pumps for flammable liquids;
——pumps intended exclusively for industrial purposes;
——pumps intended to be used in locations where special conditions prevail, such as the presence of a corrosive or explosive atmosphere (dust, vapour or gas);
——pumps incorporating chlorinators of the electrolytic type.
Note 4: Pumps incorporated in appliances are not covered by this part unless a specific reference is made.
2 Normative references
This clause of GB 4706.1-2005 is applicable except as follows.
Addition:
GB 16895.13-2002 Electrical installations of buildings - Part 7: Requirements for special installations or locations - Section 701: Locations containing a bath tub or shower basin (IEC 60364-7-701: 1984, IDT)
3 Definitions
This clause of GB 4706.1-2005 is applicable except as follows.
3.1.9 Replacement:
normal operation
operation of the appliance under the following conditions
Foreword i
IEC foreword iii
1 Scope
2 Normative references
3 Definitions
4 General requirement
5 General conditions for the tests
6 Classification
7 Marking and instructions
8 Protection against access to live parts
9 Starting of motor-operated appliances
10 Power input and current
11 Heating
12 Void
13 Leakage current and electric strength at operating temperature
14 Transient overvoltages
15 Moisture resistance
16 Leakage current and electric strength
17 Overload protection of transformers and associated circuits
18 Endurance
19 Abnormal operation
20 Stability and mechanical hazards
21 Mechanical strength
22 Construction
23 Internal wiring
24 Components
25 Supply connection and external flexible cords
26 Terminals for external conductors
27 Provision for earthing
28 Screws and connections
29 Clearances, creepage distances and solid insulation
30 Resistance to heat and fire
31 Resistance to rusting
32 Radiation, toxicity and similar hazards
Annexes
Bibliography
